GRiSO ghetto
Would you like to react to this message? Create an account in a few clicks or log in to continue.


12425 - Established June, 2013 - all GRiSO, all the time...
 
HomeRegisterLog in

 

 Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE

Go down 
3 posters
AuthorMessage
PJPR01
GRiSO Capo
GRiSO Capo
PJPR01


Posts : 192
Join date : 2018-04-24

Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Empty
PostSubject: Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE   Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Icon_minitime1Sun Feb 03, 2019 12:26 pm

2015 GRiSO 1200 SE -

Working on reloading a new Beetle Map, and also checking the throttle bodies per guidance from here, but before I get to that activity, I notice for the first time that there is an evaporative tubing that goes to a 3 way plastic T near the left hand throttle body, but there's no third tube attached there on the single portion of the T, just on both horizontal portions of the T.  

The only other evaporative tube I see NOT connected to anything descends from the tank and is far too short to connect to this T-section I believe...may have to pull the tank off to see if it's crimped there and it really should connect.

Just curious if anyone has a schematic of the evap lines handy...my diagramatic book hasn't arrived yet.  Wondering if this has anything to do with the rich fueling issues I am having that is causing the pipes to purple...would like to check this before i load the new Beetle Map and then do the throttle bodies to see if it makes any difference!

Thanks All!
Back to top Go down
beetle
GRiSO Capo
GRiSO Capo
beetle


Posts : 10056
Join date : 2013-09-30

Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Empty
PostSubject: Re: Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE   Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Icon_minitime1Sun Feb 03, 2019 1:19 pm

Vapour recovery system?

[You must be registered and logged in to see this image.]

--- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- ---
.


.
[You must be registered and logged in to see this image.]
.
In GRiSO we trust!
.
Back to top Go down
https://www.griso.org
PJPR01
GRiSO Capo
GRiSO Capo
PJPR01


Posts : 192
Join date : 2018-04-24

Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Empty
PostSubject: Re: Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE   Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Icon_minitime1Sun Feb 03, 2019 1:45 pm

Thank you...now to hunt for that hose that connects to #9! Much appreciated Mark!
Back to top Go down
GuzziSteve
Fra Cristoforo
Fra Cristoforo
GuzziSteve


Posts : 772
Join date : 2016-04-14

Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Empty
PostSubject: Re: Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE   Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Icon_minitime1Sun Feb 03, 2019 4:02 pm

I take the 'T' out and install a strait connector. No plugged hose to worry about. Then just 3 lines empty under bike. Airbox drain, tank vent and fuel cap drain. All routed to not be by the exhaust.
Back to top Go down
PJPR01
GRiSO Capo
GRiSO Capo
PJPR01


Posts : 192
Join date : 2018-04-24

Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Empty
PostSubject: Re: Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE   Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Icon_minitime1Sun Feb 03, 2019 5:36 pm

Thanks Steve...I don’t think the bike has had a canisterectomy, need to check.  Do you do a straight connector even while keeping the canister?

Good suggestion on the routing of the lines...I’ll check that!
Back to top Go down
GuzziSteve
Fra Cristoforo
Fra Cristoforo
GuzziSteve


Posts : 772
Join date : 2016-04-14

Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Empty
PostSubject: Re: Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE   Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Icon_minitime1Sun Feb 03, 2019 8:08 pm

You can't miss it, it's bolted under trans inside of R/H foot peg. I don't know why you would keep it on unless you move to CA and have to have it.
You can also just run a new piece of vacuum line from L intake to the R intake for a clean look.
It comes off w/2 bolts, back one is for frame member, front is a big button head & does nothing else.
Back to top Go down
PJPR01
GRiSO Capo
GRiSO Capo
PJPR01


Posts : 192
Join date : 2018-04-24

Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Empty
PostSubject: Re: Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE   Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Icon_minitime1Sun Feb 03, 2019 8:59 pm

Perfect thank you!

Found the hose that attaches to the T - had been tucked in way underneath...got it connected again.n Now I see where the canister is...was thinking it was tucked under the seat like the Norge, but not enough room there, so it makes sense it's hanging off the bottom. Time for surgery to remove it!

Now onto the throttle bodies...tested the screws and they were tight...hopefully that means someone hasn't messed with them and we're balanced, but worthwhile to check!
Back to top Go down
Sponsored content





Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Empty
PostSubject: Re: Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE   Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE Icon_minitime1

Back to top Go down
 
Evaporative lines T-section - only 2 tubes attached - 2015 GRiSO 1200 SE
Back to top 
Page 1 of 1
 Similar topics
-
» Dart Flyscreen Hardware Question(2015 GRiSO SE)
» Pre 2015 oil filter on 2015 GRiSO
» 2013 GRiSO front Brake lines fitting
» 2015-on GRiSO ETS help?
» 2015 GRiSO with Zard in Satin

Permissions in this forum:You cannot reply to topics in this forum
GRiSO ghetto :: The Ghetto :: GRiSOLOGY-
Jump to: