GRiSO ghetto
Would you like to react to this message? Create an account in a few clicks or log in to continue.


12425 - Established June, 2013 - all GRiSO, all the time...
 
HomeRegisterLog in

 

 Scary oil light behavior

Go down 
+3
kiwi dave
Steak
Triman023
7 posters
AuthorMessage
Triman023
Tiradritto
Tiradritto
Triman023


Posts : 306
Join date : 2014-06-05
Age : 74

Scary oil light behavior Empty
PostSubject: Scary oil light behavior   Scary oil light behavior Icon_minitime1Fri Jun 16, 2017 10:27 am

This happens when I ride my 13 GRiSO in hot conditions: A long slow up hill charity ride on a hot day or stuck in traffic for a 1/2 hour on a hot day after powering down the freeway. When I pull into a parking place within a few seconds of stopping, while the engine is idling, my oil light turns on.
Its solidly on, not flickering, I tried a quick blip of the throttle before shutdown but it stays solidly on. The engine is running no longer than 5 seconds before shut down, but no noises, just ticking over as always. This last time I also got the oil can on the LCD display. Shocked

When I let the bike sit for a 1/2 hour and check the oil its always at the correct level. Bike starts normally and runs fine for the rest of the day with no oil light appearing.

I assume (my favorite diagnostic tool) that I may have a bad oil pressure sensor. I can't think of a reason for losing oil pressure at idle when I had it all the rest of the time. No shortage of oil. I do keep the level at halfway between full and low so not to suck up oil into the airbox

What say you?  This only happens on a hot day with a bit of slow going. The engine is hot and I assume (again!) that when I stop the residual engine heat increases (no air cooling). Is it pushing the sensor over the edge or is my oil goofy?

Or was 2013 an unlucky year for Grisos? Question
Back to top Go down
Steak
Godfather
Steak


Posts : 3154
Join date : 2013-05-28
Age : 59

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Fri Jun 16, 2017 11:32 am

When it happens, just look away and save yourself the grief.

--- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- ---
[You must be registered and logged in to see this image.]

2012 MOTO GUZZI GRiSO 1200SE

2013 MOTO GUZZI STELVIO 1200NTX - Orange Blossom Special
Back to top Go down
https://www.grisoghetto.com
Triman023
Tiradritto
Tiradritto
Triman023


Posts : 306
Join date : 2014-06-05
Age : 74

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Fri Jun 16, 2017 1:55 pm

OK  I will put some black tape over the light.
Back to top Go down
kiwi dave
GRiSO Capo
GRiSO Capo
kiwi dave


Posts : 735
Join date : 2014-04-23
Age : 76

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Fri Jun 16, 2017 2:30 pm

A replacement pressure switch is cheap peace of mind. If it happens again, then you should be worried.
Back to top Go down
Triman023
Tiradritto
Tiradritto
Triman023


Posts : 306
Join date : 2014-06-05
Age : 74

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Fri Jun 16, 2017 2:32 pm

Worried most of the time anyway.
A new switch would be one less thing, also when it really fails its an oily mess!

Back to top Go down
Pete Roper
GRiSO Capo
GRiSO Capo
Pete Roper


Posts : 10420
Join date : 2013-05-29
Age : 67

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Fri Jun 16, 2017 3:29 pm

Also if the switch doesn't fix it do a bit of research on blown block to sump spacer gaskets. It's not common but it does occur.
Back to top Go down
Grisonut
GRiSO
GRiSO
Grisonut


Posts : 1406
Join date : 2014-01-02

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Sat Jun 17, 2017 5:34 am

Yep, I agree with Pete^^^^^^.
Just replaced said gasket...and my bike is a 2013 as well.
Between the sensor and gasket, there's the culprit. Wink
Back to top Go down
Triman023
Tiradritto
Tiradritto
Triman023


Posts : 306
Join date : 2014-06-05
Age : 74

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Mon Jun 19, 2017 9:46 am

Does anyone know of a write up on how to replace the gasket?
Back to top Go down
Pete Roper
GRiSO Capo
GRiSO Capo
Pete Roper


Posts : 10420
Join date : 2013-05-29
Age : 67

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Mon Jun 19, 2017 10:58 am

It's all pretty straightforward. Remove the sump, 14 bolts around the outside and 4 in the oil filter cavity, then once that is off remove the cooling oil pick up and the four bolts that hold the spacer in place. You might need to remove the side stand too but I don't think so. The spacer then comes off and you can replace the gasket and reassemble.
Back to top Go down
Grisonut
GRiSO
GRiSO
Grisonut


Posts : 1406
Join date : 2014-01-02

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Mon Jun 19, 2017 5:08 pm

The side stand has three bolts...one on the block and two on the spacer. Those two need to come off but to get to it, you have the remove the left exhaust pipe (real easy).
You also need to remove the two lower oil cooler bolts...they're secured on the spacer as well.
Back to top Go down
Nobleswood
GRiSO Capo
GRiSO Capo
Nobleswood


Posts : 582
Join date : 2016-12-20

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Mon Jun 19, 2017 7:41 pm

Look at ' Didn't want to hear this..'
There are pictures !
Back to top Go down
Triman023
Tiradritto
Tiradritto
Triman023


Posts : 306
Join date : 2014-06-05
Age : 74

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Tue Jun 20, 2017 11:49 am

Do these gaskets require 3 Bond or some other sealant? or do they go on dry?
Back to top Go down
Oz1200Guzzi
Don Abbondio
Don Abbondio
Oz1200Guzzi


Posts : 6080
Join date : 2014-03-13
Age : 69

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Tue Jun 20, 2017 3:07 pm

Dry. Assuming the mating surfaces are pristine, which they should be...
Back to top Go down
Triman023
Tiradritto
Tiradritto
Triman023


Posts : 306
Join date : 2014-06-05
Age : 74

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Tue Jun 20, 2017 4:05 pm

Thanks! Putting goop on the underside of the engine doesn't sound fun.
Back to top Go down
Triman023
Tiradritto
Tiradritto
Triman023


Posts : 306
Join date : 2014-06-05
Age : 74

Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1Tue Jun 20, 2017 10:12 pm

MG Cycle has the lovely green gaskets if anyone is looking for them
Back to top Go down
Sponsored content





Scary oil light behavior Empty
PostSubject: Re: Scary oil light behavior   Scary oil light behavior Icon_minitime1

Back to top Go down
 
Scary oil light behavior
Back to top 
Page 1 of 1
 Similar topics
-
» Electrical Problem - No rear light or tag light
» Service light and oil light coming on
» Scary sounds of GRiSO 850
» Oil light comes on
» Scary engine noise

Permissions in this forum:You cannot reply to topics in this forum
GRiSO ghetto :: The Ghetto :: GRiSOLOGY-
Jump to: